Afyonkarahisar Jeotermal Isıtma Sisteminde Oluşan Kabuklaşma ve Korozyon

Makalenin İngilizce İsmi: 
Formation of Deposit and Corrosion in Afyonkarahisar Geothermal Heating System
Makale İçerik Bilgileri
Makale Dili: 
Türkçe
Anahtar Kelimeler: 
Jeotermal su
kabuklaşma
korozyon
XRD
ICP-OES
Türkçe Özet: 

Akışkanın kimyasal içeriğine bağlı olarak oluşan kabuklaşma ve korozyon, jeotermal
sistemlerin işletilmesinde karşılaşılan önemli sorunlardan biridir. Bu çalışmada, Afyonkarahisar
jeotermal şehir ısıtma sisteminden (AFJET) alınan su örneklerinde iyon kromotografisi(IC) ve indüktif
eşlenmiş plazma optik emisyon spektrometresi (ICP-OES) analizleri gerçekleştirilmiştir. Boru içinde
oluşan kabukların XRD analizleri yaptırılmış ve TS 266'ya göre suların toplam sertlikleri analiz
edilmiştir. Yapılan XRD analizleri şehir dışı jeotermal ısıtma boru hattında CaCO kabuklaşması
olduğunu, şehir içi kuyu suyu geçen boru hattında ise Na Ca(OH) , CaCO ve MgAlSi içeren bir kabuk
oluşumu oluştuğunu göstermektedir. NaCl ile yumuşatılan kuyu suyunun geçtiği boru hattında çukur
korozyonu olmakta aynı durum jeotermal suyun geçtiği borularda da olmaktadır. Geri dönüş sularında
çözünen madde miktarlarının artması sistemde kullanılan St 37 çeliğinin suyun etkisiyle erozyona
uğrayarak çözündüğünü (korozyona uğradığını) göstermektedir.Toplam sertliklerdeki artış kabuklaşma
olayını desteklemektedir.

Key Words: 
Geothermal water
deposit
corrosion
XRD
ICP-OES
İngilizce Özet: 

The formation of deposit and corrosion, which was formed depending on the chemical
composition of the geothermal water, is one of the most serious problems at the geothermal systems. In
this study, ion chromotography (IC) and ınductively coupled plasma optical emission spectroscopy
(ICP_OES) analysis were carried out for water samples that are taken off Afyonkarahisar Geothermal
Heating System. Analysis of the deposits formed in pipeline was carried out by using X-Ray Diffraction
Technique and total hardness of water was analyzed by TS 266 method. The results of XRD analysis
showed that the deposit of CaCO formed in the suburban geothermal pipelines while the deposit of
containing Na Ca(OH) , CaCO and MgAlSi formed in the inner city well water pipelines. Pitting and
erosion corrosion occurred in the pipelines running well water decalcified with NaCl. Also same case
occurred in the geothermal pipelines. The increase of amount of dissolved substance in the return water
indicated that St37 steel was exposed to erosion corrosion. The increase of total hardness favored the
formation of deposit

Yazar Bilgileri
1. Yazar
Yazar Adı: 
Aysel BÜYÜKSAĞİŞ
Yazar Üniversitesi: 
Afyon Kocatepe Üniversitesi
Yazar Fakültesi: 
Fen Edebiyat Fakültesi
Yazar Anabilim Dalı: 
Kimya
Makale Künye Bilgisi
Makalenin Yayımlandığı Dergi: 
Jeoloji Mühendisliği Dergisi
Makale Yayın Yılı: 
2008
Cilt/Sayı: 
32
Sayı: 
1
Sayfa Aralığı: 
9-24
PDF Dosyası: 
Referanslar: 

Anonymous, 2006 .http://www.magnetixtr.
com/jeotermal.html
Banaś, J., Lelek-Borkowska, U., Mazurkiewicz, B.
ve Solarski,W., 2007,"Effect of CO and
H S on the composition and stability of
passive film on iron alloys in geothermal
water”, Electrochimica Acta, 52(18),
5704-5714
Çataltaş, İ., 1985, Kimyasal Proses Endüstrileri 1,
İnkılap Kitabevi, İstanbul, 500 sayfa
Çakır, A. ,2005, Jeotermal Su Kullanımında
Kabuklaşma Ve Korozyon Problemleri, ,
Jeotermal Enerji Semineri, TESKON,
303-316
Gallup, D.L., 1993, “The use of reducing agents for
control of ferric silicate scale deposition” ,
Geothermics, 22 (1), 39-48
Gallup, D.L., 1998, “Inhibition of silica
precipitation “
A p p l i e d Thermal E n g i n e e r i n g
18 (6), 19
Gallup, D. L. ve Barcelon, E., 2005,
“Investigations of organic inhibitors for
silica scale control from geothermal
brines–II”, Geothermics 34 (6), 756-771
Batis, G., Kouloumbi, N. ve Kotsakou, K., 1997,
“Corrosion and protection of carbon steel
in low enthalpy geothermal fluids. The
case of SOUSAKI IN Greece”,
Geothermics, 26 (1), 65-82
Gendenjamts, OE., 2005 The United Nations
University, Geothermal Training
Programme, 'Interpretation Of Chemical
Composition Of Geothermal Fluids From
Árskógsströnd, Dalvík, And Hrísey,
NIceland And In The Khangai Area,
Mongolia', Reports Number 10,
Reykjavik, Iceland
Higgins, J. P. Ve Hard, B. C., 2003,
“Bıoremedıatıon of Rock Draınage Usıng
Sulphate-Reducıng Bacterıa”,
SUDBURY 2003,
www.jacqueswhitford.com
Kubiak, J. A. ve Urquiza-beltrán, G., 2002,
“Simulation of the effect of scale
deposition on a geothermal turbine”,
Geothermics, 31(5),2002, 545-562
Mergen, H., Mergen, B.E., Erdoğmuş, A.B., 2006,
“Jeotermal Enerji ve Balneoterapi
Uygulamaları”, FTR Bil Der J PMR
Sci,9(3), 108-113
Mertoğlu, O., 2000, Türkiyede Jeotermal Enerji
Uygulamaları Ve Gelişimi, İller Bankası
Genel Müdürlüğü, Yerel Yönetimlerde
Jeotermal Enerji Ve Jeoteknik
Uygulamalar Sempozyumu, Editör:Ö.
Ersin Gırbalar ,Aydoğdu Ofset , Ankara,
1-9
Mornet ve Neville (2002) Morizot,A. P. ve Neville,
A., 2002, “Insights into Electrodeposition
of an Inhibitor Film and Its Inhibitive
Eff e c t s on Calcium Carbonate
Deposition”, Journal of Colloid and
Interface Science, 245 40–49
Mutlu, H., 1997, “Gazlıgöl (Afyon) Termal ve
Maden Sularının Jeokimyasal Özellikleri
ve Jeotermometre Uygulamaları”, Jeoloji
Müh. Dergisi, 50
Özbek, T., 2000, Jeotermal Akışkanın Entegre
Olarak sağlık ve Termal Turizmde
Değerlendirilmesi, İller Bankası Genel
Müdürlüğü,Yerel Yönetimlerde Jeotermal
Enerji Ve Jeoteknik Uygumlalar
Sempozyumu, Editör:Ö. Ersin Gırbalar
,Aydoğdu Ofset,Ankara, 241-263
Patzay, G., Stahl, G., Karman, F.H. And Kalman,
E., 1998, Modeling of scale formation and
corrosion from geothermal water,
Electrochim.Acta, 43, p.137-147
Al-Rawajfeh, A. E., Gladeb, H., Ulrich, J., 2005,
Scaling in multiple-effect distillers: the
role of CO2 release, Desalination, 182,
209–219
Richter, S., Hilbert, L.R., ve Thorarinsdottir, R.I.,
2006, “On-line corrosion monitoring in
geothermal district heating systems. I.
General corrosion rates”, Corrosion
Science, 48(7), 1770-1778
Sampedro, J. A., Rosas, N. ve Díaz, R.,
Domínguez , B.,1998, “Developments in
geothermal energy in Mexico—part
nineteen. Corrosion in Mexican
geothermal wells”, Heat Recovery
Systems andCHP, 8 (4), 355-362
Soylemezoglu, S. ve Harper, R. , 1982, “Oxygen
ingress into geothermal steam and its effect on corrosion of low carbon steel at
Broadlands, New Zealand”, Geothermics,
11(1), 31-42
Şahmurova, A., Hepsağ, E. Ve Özkan, A., 2005,
“Azerbaycan'ın Yeraltısularında Eser
Element Konsantrasyonları ve Florür
Seviyesinin Değerlendirilmesi”, Trakya
Univ J Sci, 6(2), 57-63
Üneri, S., 1998, Korozyon ve Önlenmesi,
Korozyon DerneğiYayınları,Ankara,413 s
Xyla, A. G., Mikroyannidis, J. ve Koutsoukos, P.
G., 1992, The inhibition of calcium
carbonate precipitation in aqueous media
by organophosphorus compounds, Journal
of Colloid and Interface Science, 153 (2),
537-551TS 266
(www.ansiklopedim.com)
(http://envisjnu.net/newslet/v7n3/surface.html)
(http://www.kazancionline.com/
http://www.mayerkimya.com/endustriyel.htm
http://www.cevretek.com/
http://www.coskunaritma.com/anatur.asp
http://www.detayaritma.com/)

Türkiye’nin ilk İşletme Fakültesi olan İstanbul Üniversitesi İşletme Fakültesi bir ilke daha imza atmaya hazırlanıyor. Arastirmax.com "1. Liselerarası İşletme ve Ekonomi Proje Yarışması"nın sponsorlarından biri olmaktan gurur duymakta.